Fillable Printable Temperature Log for Refrigerator
Fillable Printable Temperature Log for Refrigerator
Temperature Log for Refrigerator
If you have a vaccine storage issue, also complete “Vaccine Storage Troubleshooting Record” found on page 3.
Temperature Log for Refrigerator – Fahrenheit
Page 1 of 3
DAYS 1
–
15
Monitor temperatures closely!
1. Write your initials below in “Staff Initials,” and note the time in “Exact Time.”
2. Record temps twice each workday.
3. Record the min/max temps once each workday—preferably in the morning.
4. Put an “X” in the row that corresponds to the refrigerator’s temperature.
5. If any out-of-range temp, see instructions to the right.
6. After each month has ended, save each month’s log for 3 years, unlessstate/local
jurisdictions require a longer period.
Take action if temp is out of range—too warm (above 46ºF) or too cold (below 35ºF).
1. Label exposed vaccine “do not use,” and store it under properconditions as quickly as possible.
Do not discard vaccines unlessdirected to by your state/local health department and/or the
manufacturer(s).
2. Record the out-of-range temps and the room temp in the “Action” area on the bottom of the log.
3. Notify your vaccine coordinator, or call the immunizationprogram at your state or local health
department for guidance.
4. Document the action taken on the “Vaccine Storage Troubleshooting Record” on page 3.
Month
/
Year VFC PIN or other ID #
Facility Name
F
°
Day of Month 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Staff Initials
Exact Time
Min/Max Temp
(since previous reading)
Danger! Temperatures above 46ºF are too warm! Write any out-of-range temps and room temp on the lines below and call your state or local health department immediately!
46
˚
F
45
˚
F
44
˚
F
43
˚
F
42
˚
F
41
˚
F
40
˚
F
39
˚
F
38
˚
F
37
˚
F
36
˚
F
35
˚
F
Danger! Temperatures below 35ºF are too cold! Write any out-of-range temps and room temp on the lines below and call your state or local health department immediately!
Write any out-of-range
temps (above 46ºF
or below 35ºF) here:
Room Temperature
am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm
acceptable temperaturesaction
Aim for 40
º
Technical content reviewed by the Centers for Disease Control and Prevention
Immunization Action Coalition
1573 Selby Avenue
•
St. Paul, MN 55104
•
651
-
647
-
9009
•
Adapted with appreciation from California Department of Public Health
distributed by the
Temperature Log for Refrigerator – Fahrenheit
Page 2 of 3
DAYS 16
–
31
Monitor temperatures closely!
1. Write your initials below in “Staff Initials,” and note the time in “Exact Time.”
2. Record temps twice each workday.
3. Record the min/max temps once each workday—preferably in the morning.
4. Put an “X” in the row that corresponds to the refrigerator’s temperature.
5. If any out-of-range temp, see instructions to the right.
6. After each month has ended, save each month’s log for 3 years, unlessstate/local
jurisdictions require a longer period.
Take action if temp is out of range—too warm (above 46ºF) or too cold (below 35ºF).
1. Label exposed vaccine “do not use,” and store it under properconditions as quickly as possible.
Do not discard vaccines unlessdirected to by your state/local health department and/or the
manufacturer(s).
2. Record the out-of-range temps and the room temp in the “Action” area on the bottom of the log.
3. Notify your vaccine coordinator, or call the immunizationprogram at your state or local health
department for guidance.
4. Document the action taken on the “Vaccine Storage Troubleshooting Record” on page 3.
Month
/
Year VFC PIN or other ID #
Facility Name
F
°
Day of Month 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31
Staff Initials
Exact Time
Min/Max Temp
(since previous reading)
Danger! Temperatures above 46ºF are too warm! Write any out-of-range temps and room temp on the lines below and call your state or local health department immediately!
46
˚
F
45
˚
F
44
˚
F
43
˚
F
42
˚
F
41
˚
F
40
˚
F
39
˚
F
38
˚
F
37
˚
F
36
˚
F
35
˚
F
Danger! Temperatures below 35ºF are too cold! Write any out-of-range temps and room temp on the lines below and call your state or local health department immediately!
Write any out-of-range
temps (above 46ºF
or below 35ºF) here:
Room Temperature
am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm
acceptable temperaturesaction
am pm
Aim for 40
º
If you have a vaccine storage issue, also complete “Vaccine Storage Troubleshooting Record” found on page 3.
Technical content reviewed by the Centers for Disease Control and Prevention
Immunization Action Coalition
1573 Selby Avenue
•
St. Paul, MN 55104
•
651
-
647
-
9009
•
Adapted with appreciation from California Department of Public Health
distributed by the
Date & Time of Event
If multiple, related events occurred,
see Description of Event below.
Storage Unit Temperature
at the time the problem was discovered
Room Temperature
at the time the problem was discovered
Person Completing Report
Date: Temp when discovered: Temp when discovered: Name:
Time: Minimum temp: Maximum temp: Comment (optional): Title: Date:
Description of Event
(If multiple, related events occurred, list each date, time, and length of time out of storage.)
• General description (i.e., what happened?)
• Estimated length of time between event and last documented reading of storage temperature in acceptable range (35
o
to 46
o
F [2
o
to 8
o
C] for refrigerator; -58º to 5ºF [-50
o
to -15
o
C] for freezer)
• Inventory of affected vaccines, including (1) lot #s and (2) whether purchased with public (for example, VFC) or private funds (Use separate sheet if needed, but maintain the inventory with this troubleshooting record.)
• At the time of the event, what else was in the storage unit? For example, were there water bottles in the refrigerator and/or frozen coolant packs in the freezer?
• Prior to this event, have there been any storage problems with this unit and/or with the affected vaccine?
• Include any other information you feel might be relevant to understanding the event.
Action Taken
(Document thoroughly. This information is critical to determining whether the vaccine might still be viable!)
• When were the affected vaccines placed in proper storage conditions? (Note: Do not discard the vaccine. Store exposed vaccine in proper conditions and label it “do not use” until after you can discuss with your state/
local health department and/or the manufacturer[s].)
• Who was contacted regarding the incident? (For example, supervisor, state/local health department, manufacturer—list all.)
• IMPORTANT: What did you do to prevent a similar problem from occurring in the future?
Results
• What happened to the vaccine? Was it able to be used? If not, was it returned to the distributor? (Note: For public-purchase vaccine, follow your state/local health department instructions for vaccine disposition.)
Vaccine Storage Troubleshooting Record
(check one)
□Refrigerator Freezer□
Use this form to document any unacceptable vaccine storage event, such as exposure of refrigerated vaccines to temperatures that are outside the manufacturers' recommended storage ranges.
A fillable troubleshooting record (i.e., editable PDF or WORD document) can also be found at www.immunize.org/clinic/storage-handling.asp.
Immunization Action Coalition
1573 Selby Avenue
•
St. Paul, MN 55104
•
651
-
647
-
9009
•
distributed by the
Technical content reviewed by the Centers for Disease Control and Prevention
Page 3 of 3
Date & Time of Event
If multiple, related events occurred,
see Description of Event below.
Storage Unit Temperature
at the time the problem was discovered
Room Temperature
at the time the problem was discovered
Person Completing Report
Date: (see below) Temp when discovered: 45ºF Temp when discovered: 77ºF Name: Nancy Nurse
Time: (see below) Minimum temp: 38ºF Maximum temp:
53ºF
Comment (optional):
temp is approx Title: VFC Coordinator Date: 6/24/13
Results
• What happened to the vaccine? Was it able to be used? If not, was it returned to the distributor? (Note: For public-purchase vaccine, follow your state/local health department instructions for vaccine disposition.)
Late on Monday, I talked with Victor regarding continued use of vaccine. Victor had checked with manufacturers which confirmed that vaccine is
acceptable for use. He told me that vaccine could therefore be removed from quarantine. I discussed the entire situation with Susie Supervisor and
Dr. Director (clinic medical director) who agreed that we could put vaccine back in use.
Vaccine Storage Troubleshooting Record
(check one)
□Refrigerator Freezer□
Use this form to document any unacceptable vaccine storage event, such as exposure of refrigerated vaccines to temperatures that are outside the manufacturers' recommended storage ranges.
A fillable troubleshooting record (i.e., editable pdf or WORD document) can also be found at www.immunize.org/clinic/storage-handling.asp
E
x
a
m
p
l
e
Description of Event
(If multiple, related events occurred, list each date, time, and length of time out of storage.)
• General description (i.e., what happened?)
• Estimated length of time between event & last documented reading of storage temperature in acceptable range (35
o
to 46
o
F [2
o
to 8
o
C] for refrigerator; -58º to 5ºF [-50
o
to -15
o
C] for freezer)
• Inventory of affected vaccines, including (1) lot #s and (2) whether purchased with public (for example, VFC) or private funds (Use separate sheet if needed, but maintain the inventory with this troubleshooting record)
• At the time of the event, what else was in the storage unit? For example, were there water bottles in the refrigerator and/or frozen coolant packs in the freezer?
• Prior to this event, have there been any storage problems with this unit and/or with the affected vaccine?
• Include any other information you feel might be relevant to understanding the event.
Vaccines currently stored appropriately at 45ºF. Refrigerator and vaccines labeled "Do Not Use."
My State Immunization Program contacted at 8:30 am. Spoke with Victor Vaccine. Provided Victor with details of event and list of vaccines.
Vaccine to remain quarantined until we hear back from Victor.
Called electric company and confirmed 2 short power outages during weekend.
Checked refrigerator seals
called refrigerator maintenance company to replace seals.
Checked plug on unit
placed tape over plug to prevent inadvertent dislodging. Plan to purchase plug guard.
Plan to follow up with Immunization Program on data loggers with alarms that could be sent to coordinator and back-up phones.
Action Taken
(Document thoroughly. This information is critical to determining whether the vaccine might still be viable!)
• When were the affected vaccines placed in proper storage conditions? (Note: Do not discard the vaccine. Store exposed vaccine in proper conditions and label it “do not use” until after you can discuss with your
state/local health department and/or the manufacturer[s].)
• Who was contacted regarding the incident? (For example, supervisor, state/local health department, manufacturer—list all.)
• IMPORTANT: What did you do to prevent a similar problem from occurring in the future?
At 8 am on Monday (6/24/13) morning when clinic opened, identified 4 temperature excursions over the weekend in refrigerator with readings
as high as 54°, 50°, 49° & 53°F in primary vaccine storage unit #1. Recordings taken every 15 min on calibrated digital data logger overnight.
Data logger probe in glycol located in middle of refrigerator with vaccines.
Total time out of range: approximately 3 hrs — maximum temp 53°F (see attached document of continuous temp readings)
Inventory of vaccines: see attached
Water bottles in refrigerator door. No vaccine stored in freezer. No problems with storage unit prior to Saturday night. Thunderstorms in area over
weekend may have affected power.
Immunization Action Coalition
1573 Selby Avenue
•
St. Paul, MN 55104
•
651
-
647
-
9009
•
distributed by the
Technical content reviewed by the Centers for Disease Control and Prevention
Date & Time of Event
If multiple, related events occurred,
see Description of Event below.
Storage Unit Temperature
at the time the problem was discovered
Room Temperature
at the time the problem was discovered
Person Completing Report
Date: 7/16/2013 Temp when discovered: 28ºF Temp when discovered: 77ºF Name: Nancy Nurse
Time: 8:00 am Minimum temp: 28ºF Maximum temp: 42ºF
Comment (optional): temp is approx
Title: VFC Coordinator Date: 7/15/13
Results
• What happened to the vaccine? Was it able to be used? If not, was it returned to the distributor? (Note: For public-purchase vaccine, follow your state/local health department instructions for vaccine disposition.)
After fridge thermostat repaired, monitored temps in empty fridge for 1 week, per state requirements. Fridge maintained 38 º-40ºF temps for entire
week. Submitted repair documentation and data logger readings to Victor Vaccine for approval and ordered replacement vaccines. Victor had checked
with manufacturers who confirmed that all vaccines in fridge EXCEPT MMR were no longer viable and should be returned per state policy
guidelines. MMR may be used because pkg insert allows storage down to -58ºF. Discussed entire situation with Susie Supervisor and clinic
director, Dr. Director, who agreed on continued use of MMR . Will continue to monitor fridge closely to watch for pattern of temp fluctuations
indicating potential problem with thermostat. If problems, contact Victor Vaccine for advice on purchasing new fridge meeting criteria for
appropriate vaccine storage.
Vaccine Storage Troubleshooting Record
(check one)
□Refrigerator Freezer□
Use this form to document any unacceptable vaccine storage event, such as exposure of refrigerated vaccines to temperatures that are outside the manufacturers' recommended storage ranges.
A fillable troubleshooting record (i.e., editable pdf or WORD document) can also be found at www.immunize.org/clinic/storage-handling.asp
E
x
a
m
p
l
e
When checked main clinic fridge (in lab) at 8:00 am on Tuesday, 7/16/2013, digital readout on data logger read 28ºF. Data logger located in
center of fridge with probe in glycol . Review of computer readings (taken every 15 minutes) showed steady drop in temps from 42ºF at 8:15 pm
(7/15/2013) to 28ºF reading discovered when arrived at clinic on Tuesday morning (7/16/2013). Readings hit 34 ºF at 11 pm (7/15) and 32 ºF
at 2 am (7/16). Total time out of recommended storage temps = 9 hours, with 6 hours at freezing or below (see attached document of continuous
temp readings). Inventory of vaccines attached.
Water bottles in refrigerator door and crisper area. No vaccines stored in freezer. No recent adjustments to temp controls and no previous temp ex-
cursions noted with this refrigerator before 7/15.
Upon discovery, vaccines marked “Do Not Use” and stored in 2nd clinic fridge (in exam room #3 at 41 ºF). Also placed “Do Not Use” note on main
fridge in lab. Notified Susie Supervisor about the issue. Contacted Victor Vaccine at My State Immunization Program at 8:30 am. Provided Victor
with details of event and list of vaccines in fridge. Victor said to maintain vaccines in 2nd fridge and that he would check with manufacturers to
determine next steps.
Called Jim’s Appliance Repair to examine fridge. Repairman found and replaced faulty thermostat in unit.
Reset data logger on center shelf in fridge with probe in glycol .
Description of Event
(If multiple, related events occurred, list each date, time, and length of time out of storage.)
• General description (i.e., what happened?)
• Estimated length of time between event & last documented reading of storage temperature in acceptable range (35
o
to 46
o
F [2
o
to 8
o
C] for refrigerator; -58º to 5ºF [-50
o
to -15
o
C] for freezer)
• Inventory of affected vaccines, including (1) lot #s and (2) whether purchased with public (for example, VFC) or private funds (Use separate sheet if needed, but maintain the inventory with this troubleshooting record)
• At the time of the event, what else was in the storage unit? For example, were there water bottles in the refrigerator and/or frozen coolant packs in the freezer?
• Prior to this event, have there been any storage problems with this unit and/or with the affected vaccine?
• Include any other information you feel might be relevant to understanding the event.
Action Taken
(Document thoroughly. This information is critical to determining whether the vaccine might still be viable!)
• When were the affected vaccines placed in proper storage conditions? (Note: Do not discard the vaccine. Store exposed vaccine in proper conditions and label it “do not use” until after you can discuss with your
state/local health department and/or the manufacturer[s].)
• Who was contacted regarding the incident? (For example, supervisor, state/local health department, manufacturer—list all.)
• IMPORTANT: What did you do to prevent a similar problem from occurring in the future?
Immunization Action Coalition
1573 Selby Avenue
•
St. Paul, MN 55104
•
651
-
647
-
9009
•
distributed by the
Technical content reviewed by the Centers for Disease Control and Prevention
Temperature Log for Freezer – Fahrenheit
Page 1 of 3
DAYS 1
–
15
Monitor temperatures closely!
1. Write your initials below in “Staff Initials,” and note the time in “Exact Time.”
2. Record temps twice each workday.
3. Record the min/max temps once each workday—preferably in the morning.
4. Put an “X” in the row that corresponds to the freezer’s temperature.
5. If any out-of-range temp, see instructions to the right.
6. After each month has ended, save each month’s log for 3 years, unlessstate/local
jurisdictions require a longer period.
Take action if temp is out of range—too warm (above 5ºF) or too cold (below
-
58ºF).
1. Label exposed vaccine “do not use,” and store it under properconditions as quickly as possible.
Do not discard vaccines unlessdirected to by your state/local health department and/or the
manufacturer(s).
2. Record the out-of-range temps and the room temp in the “Action” area on the bottom of the log.
3. Notify your vaccine coordinator, or call the immunizationprogram at your state or local health
department for guidance.
4. Document the action taken on the “Vaccine Storage Troubleshooting Record” on page 3.
Month
/
Year VFC PIN or other ID #
Facility Name
F
°
If you have a vaccine storage issue, also complete “Vaccine Storage Troubleshooting Record” found on page 3.
Technical content reviewed by the Centers for Disease Control and Prevention
Immunization Action Coalition
1573 Selby Avenue
•
St. Paul, MN 55104
•
651
-
647
-
9009
•
Adapted with appreciation from California Department of Public Health
distributed by the
Day of Month 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Staff Initials
Exact Time
Min/Max Temp
(since previous reading)
Danger! Temperatures above 5ºF are too warm! Write any out-of-range temps and room temp on the lines below and call your state or local health department immediately!
5
˚
F
4
˚
F
3
˚
F
2
˚
F
1
˚
F
0
˚
F
-
1
˚
F
-
2
˚
F
-
3
˚
F
-
4
˚
F
-
58
˚
F to
-
5
˚
F
Write any out-of-range
temps (above 5ºF
or below
-
58ºF) here.
Room Temperature
am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm
a c c e p t a b l e
t e m p e r a t u r e s
a c t i o n
Temperature Log for Freezer – Fahrenheit
Page 2 of 3
DAYS 16
–
31
Monitor temperatures closely!
1. Write your initials below in “Staff Initials,” and note the time in “Exact Time.”
2. Record temps twice each workday.
3. Record the min/max temps once each workday—preferably in the morning.
4. Put an “X” in the row that corresponds to the freezer’s temperature.
5. If any out-of-range temp, see instructions to the right.
6. After each month has ended, save each month’s log for 3 years, unlessstate/local
jurisdictions require a longer period.
Take action if temp is out of range—too warm (above 5ºF) or too cold (below
-
58ºF).
1. Label exposed vaccine “do not use,” and store it under properconditions as quickly as possible.
Do not discard vaccines unlessdirected to by your state/local health department and/or the
manufacturer(s).
2. Record the out-of-range temps and the room temp in the “Action” area on the bottom of the log.
3. Notify your vaccine coordinator, or call the immunizationprogram at your state or local health
department for guidance.
4. Document the action taken on the “Vaccine Storage Troubleshooting Record” on page 3.
Month
/
Year VFC PIN or other ID #
Facility Name
F
°
If you have a vaccine storage issue, also complete “Vaccine Storage Troubleshooting Record” found on page 3.
Adapted with appreciation from California Department of Public Health
Technical content reviewed by the Centers for Disease Control and Prevention
Immunization Action Coalition
1573 Selby Avenue
•
St. Paul, MN 55104
•
651
-
647
-
9009
•
distributed by the
Day of Month 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31
Staff Initials
Exact Time
Min/Max Temp
(since previous reading)
Danger! Temperatures above 5ºF are too warm! Write any out-of-range temps and room temp on the lines below and call your state or local health department immediately!
5
˚
F
4
˚
F
3
˚
F
2
˚
F
1
˚
F
0
˚
F
-
1
˚
F
-
2
˚
F
-
3
˚
F
-
4
˚
F
-
58
˚
F to
-
5
˚
F
Write any out-of-range
temps (above 5ºF
or below
-
58ºF) here.
Room Temperature
am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm am pm
a c c e p t a b l e
t e m p e r a t u r e sa c t i o n
Date & Time of Event
If multiple, related events occurred,
see Description of Event below.
Storage Unit Temperature
at the time the problem was discovered
Room Temperature
at the time the problem was discovered
Person Completing Report
Date: Temp when discovered: Temp when discovered: Name:
Time: Minimum temp: Maximum temp: Comment (optional): Title: Date:
Description of Event
(If multiple, related events occurred, list each date, time, and length of time out of storage.)
• General description (i.e., what happened?)
• Estimated length of time between event and last documented reading of storage temperature in acceptable range (35
o
to 46
o
F [2
o
to 8
o
C] for refrigerator; -58º to 5ºF [-50
o
to -15
o
C] for freezer)
• Inventory of affected vaccines, including (1) lot #s and (2) whether purchased with public (for example, VFC) or private funds (Use separate sheet if needed, but maintain the inventory with this troubleshooting record.)
• At the time of the event, what else was in the storage unit? For example, were there water bottles in the refrigerator and/or frozen coolant packs in the freezer?
• Prior to this event, have there been any storage problems with this unit and/or with the affected vaccine?
• Include any other information you feel might be relevant to understanding the event.
Action Taken
(Document thoroughly. This information is critical to determining whether the vaccine might still be viable!)
• When were the affected vaccines placed in proper storage conditions? (Note: Do not discard the vaccine. Store exposed vaccine in proper conditions and label it “do not use” until after you can discuss with your state/
local health department and/or the manufacturer[s].)
• Who was contacted regarding the incident? (For example, supervisor, state/local health department, manufacturer—list all.)
• IMPORTANT: What did you do to prevent a similar problem from occurring in the future?
Results
• What happened to the vaccine? Was it able to be used? If not, was it returned to the distributor? (Note: For public-purchase vaccine, follow your state/local health department instructions for vaccine disposition.)
Vaccine Storage Troubleshooting Record
(check one)
□Refrigerator Freezer□
Page 3 of 3
Use this form to document any unacceptable vaccine storage event, such as exposure of refrigerated or frozen vaccines to temperatures that are outside the manufacturers' recommended storage ranges.
A fillable troubleshooting record (i.e., editable PDF or WORD document) can also be found at www.immunize.org/clinic/storage-handling.asp.
Immunization Action Coalition
1573 Selby Avenue
•
St. Paul, MN 55104
•
651
-
647
-
9009
•
distributed by the
Technical content reviewed by the Centers for Disease Control and Prevention
Date & Time of Event
If multiple, related events occurred,
see Description of Event below.
Storage Unit Temperature
at the time the problem was discovered
Room Temperature
at the time the problem was discovered
Person Completing Report
Date: 7/16/2013 Temp when discovered: 55ºF Temp when discovered: 77ºF Name: Nancy Nurse
Time: 8:00 am Minimum temp: 2ºF Maximum temp: 57ºF
Comment (optional): temp is approx
Title: VFC Coordinator Date: 7/15/13
Vaccine Storage Troubleshooting Record
(check one)
□Refrigerator Freezer□
Use this form to document any unacceptable vaccine storage event, such as exposure of refrigerated or frozen vaccines to temperatures that are outside the manufacturers' recommended storage ranges.
A fillable troubleshooting record (i.e., editable pdf or WORD document) can also be found at www.immunize.org/clinic/storage-handling.asp
Description of Event
(If multiple, related events occurred, list each date, time, and length of time out of storage.)
• General description (i.e., what happened?)
• Estimated length of time between event & last documented reading of storage temperature in acceptable range (35
o
to 46
o
F [2
o
to 8
o
C] for refrigerator; -58º to 5ºF [-50
o
to -15
o
C] for freezer)
• Inventory of affected vaccines, including (1) lot #s and (2) whether purchased with public (for example, VFC) or private funds (Use separate sheet if needed, but maintain the inventory with this troubleshooting record)
• At the time of the event, what else was in the storage unit? For example, were there water bottles in the refrigerator and/or frozen coolant packs in the freezer?
• Prior to this event, have there been any storage problems with this unit and/or with the affected vaccine?
• Include any other information you feel might be relevant to understanding the event.
Upon discovery, vaccines marked “Do Not Use” and stored in 2nd clinic freezer (in exam room #3) at 1
°
F. Also placed “Do Not Use” note on main
freezer in lab. Notified Susie Supervisor about the issue. Contacted Victor Vaccine at My State Immunization Program at 8:30 am. Provided Victor
with details of event and list of vaccines in freezer. Victor said to maintain vaccines in 2nd freezer and that he would check with Merck (manufac-
turer of all the affected vaccines) to determine next steps. Called Jim’s Appliance Repair to examine freezer. Repairman replaced freezer door gasket
and recommended removal of ~½ of freezer packs in door because size and weight of packs potentially interfered with door closing completely. No
problems identified with thermostat or other mechanical components.
Removed half of freezer packs located in shelf in door, per recommendation . Reset data logger on center shelf of freezer with probe in glycol . All
staff received refresher training on ensuring freezer door is closed after each use, and a reminder sign was placed prominently on freezer door.
Results
• What happened to the vaccine? Was it able to be used? If not, was it returned to the distributor? (Note: For public-purchase vaccine, follow your state/local health department instructions for vaccine disposition.)
After repair, monitored temps in empty freezer for 1 week, per state requirements. Freezer maintained 0–2°F temps for entire week. Submitted repair
documentation and data logger readings to Victor Vaccine for approval and ordered replacement vaccines. Victor had checked with manufacturer.
After reviewing history and stability data, manufacturer stated vaccine was acceptable for continued use. Discussed entire situation with Susie
Supervisor and clinic director, Dr. Immunize, who agreed on continued use of vaccine. Vaccine to be labeled as "use first."
Action Taken
(Document thoroughly. This information is critical to determining whether the vaccine might still be viable!)
• When were the affected vaccines placed in proper storage conditions? (Note: Do not discard the vaccine. Store exposed vaccine in proper conditions and label it “do not use” until after you can discuss with your
state/local health department and/or the manufacturer[s].)
• Who was contacted regarding the incident? (For example, supervisor, state/local health department, manufacturer—list all.)
• IMPORTANT: What did you do to prevent a similar problem from occurring in the future?
When checked vaccine freezer (in lab) at 8:00 am on Tuesday, 7/16/2013, discovered freezer door slightly ajar. Digital readout on data logger
read 55°F. Data logger located in center of freezer with probe in glycol . Review of computer readings (taken every 15 minutes) showed steady rise
in temps from 2 °F at 5:30 pm (7/15/2013) to 55 °F reading discovered when arrived at clinic on Tuesday morning (7/16/2013). Readings hit
6°F at 11 pm (7/15) and 45 °F at 2 am (7/16). Total time out of recommended storage temp of 5 °F or below = 9 hours. (See attached document of
continuous temp readings.) Freezer contained Varivax, ProQuad, and Zostavax (inventory attached).
Frozen packs stored on freezer floor and shelves in door. No recent adjustments to temp controls and no previous temp excursions noted with this
freezer before 7/15.
Immunization Action Coalition
1573 Selby Avenue
•
St. Paul, MN 55104
•
651
-
647
-
9009
•
distributed by the
Technical content reviewed by the Centers for Disease Control and Prevention
